Examples



mdbootstrap.com



 
Article
2021

Inhibition of Copper Corrosion in Acid Rain Solution Using the Imidazole Derivatives


 Ana Simonović Ana Simonović, Marija Petrović MihajlovićMarija Petrović Mihajlović, Milan RadovanovićMilan Radovanović, Žaklina TasićŽaklina Tasić, Milan AntonijevićMilan Antonijević
Russian Journal of Electrochemistry
https://doi.org/10.1134/S102319352012023X
Abstract / Full Text

The effect of the imidazole derivatives on corrosion behavior of copper in acid rain solution was investigated. Electrochemical methods, quantum chemical calculations and SEM–EDS analysis was used during the work. Results show that inhibition efficiency of 1,1′-sulfonylimidazole, 2-mercapto-1-methylimidazole and 1,2-dimethylimidazole improves with the increase of inhibitors concentration. Surface analysis confirmed that a protective layer is formed on the electrode surface. SEM–EDS analysis of the copper electrode surface confirmed adsorption of inhibitor on active sites on electrode surface. Adsorption of inhibitors in acid rain solution follows the Langmuir adsorption isotherm. Quantum chemical calculations confirmed results obtained by electrochemical measurements.

Author information
  • Technical Faculty in Bor, University of Belgrade, 19210, Bor, Serbia Ana Simonović, Marija Petrović Mihajlović, Milan Radovanović, Žaklina Tasić & Milan Antonijević
References
  1. Zhang, J., Zheng, L., and Guo-Cheng, H., Inhibition of copper corrosion by the formation of Schiff base self-assembled monolayers, Appl. Surf. Sci., 2016, vol. 389, p. 601.
  2. Thanapackiam, P., Kumarvel Mallaiya Rameshkumar, S., and Subramanian, S.S., Inhibition of coorosion of copper in acids by norfloxacin, Anti-Corros. Methods Mater., 2017, vol. 64, no. 1, p. 92.
  3. Bi, H., Burstein, G.T., and Rodriguez, B.B., Some aspects of the role of inhibitors in the corrosion of copper in tap water as observed by cyclic voltammetry, Corros. Sci., 2016, vol. 102, p. 510.
  4. Migahed, M.A., El-Rabiei, M.M., and Nady, H., Synthesis, characterization of some ethoxylated tolyltriazole derivatives and evaluation of their performance as corrosion inhibitors for Cu-10 Al alloy in seawater, J. Environ. Chem. Eng., 2016, vol. 4, p. 3741.
  5. Radovanović, M., Petrović, M., and Simonović A., Cysteine as a green corrosion in inhibitor for Cu37Zn brass in neutral and weakly alkaline sulphate solutions, Environ. Sci. Pollut. Res., 2013, vol. 20, no. 7, p. 4370.
  6. Simonović, A., Petrović, M., and Radovanović, M., Inhibition of copper corrosion in acidic sulphate media by eco-friendly amino acid compound, Chem. Pap., 2014, vol. 68, no. 3, p. 362.
  7. Ismail, K.M., Evaluation of cysteine as environmentally friendly corrosion inhibitor for copper in neutral and acidic chloride solution, Electrochim. Acta, 2007, vol. 52, no. 28, p. 7811.
  8. Tian, H., Li, W., and Cao, K., Potent inhibition of copper corrosion in neutral chloride media by novel non-toxic thiadiazole derivatives, Corros. Sci., 2013, vol. 73, p. 281.
  9. El-Sayed Sherif, M., Erasmus, R.M., and Comins, J.D., Corrosion of copper in aerated acidic pickling solutions and its inhibition by 3-amino-1,2,4-triazole-5-thiole, J. Colloid. Interface Sci., 2007, vol. 306, p. 96.
  10. Morreti, G. and Guidi, F., Tryptophan as copper corrosion inhibitor in 0.5 M aerated sulfuric acid, Corros. Sci., 2002, vol. 44, p. 1995.
  11. Otmacic, H. and Stupnisek-Lisac, E., Copper corrosion inhibitors in near neutral media, Electrochim. Acta, 2003, vol. 48, p. 985.
  12. Qafsaoui, W., Blanc, C., and Pebere, N., Quantitative characterization of protective films grown on copper in the presence of different triazole derivative inhibitors, Electrochim. Acta, 2002, vol. 47, p. 4339.
  13. Mousavi, M., Mohammadalizdadeh, M., and Khosravan, A., Theoretical investigation of corrosion inhibition effect of imidazole and its derivatives on mild steel usin cluster model, Corros. Sci., 2011, vol. 53, p. 3086.
  14. Otmacic Curkovic, H., Stupnisek-Lisac, E., and Takenouti, H., The influence of pH value on the efficiency of imidazole based corrosion inhibitors of copper, Corros. Sci., 2010, vol. 52, p. 398.
  15. Žerjav, G., Lanzuatti, A., and Andreatta, F., Characterization of self-assembled layers made with stearic acid, benzotriazole, or 2-mercaptobenzoimidazole on surface of copper for corrosion protection in simulated urban rain, Mater. Corros., 2017, vol. 68, p. 30.
  16. Žerjav, G. and Milošev, I., Carboxylic acids as corrosion inhibitors for Cu, Zn and brasses in simulated urban rain, Int. J. Electrochem. Sci., 2014, vol. 9, no. 5, p. 2696.
  17. Kosec, T., Ropert, P., and Legat, A., Raman investigation of artificial patinas on recent bronze-part II: Urban rain exposure, J. Raman Spectrosc., 2012, vol. 43, no. 11, p. 1587.
  18. Saifi, H., Bernard, M.C., and Joiret, S., Corrosion inhibitive action of cysteine on Cu –30Ni alloy in aerated 0.5 N H2SO4, Mater. Chem. Phys., 2010, vol. 120, p. 661.
  19. Oguzie, E. E., Li, Y., and Wang, F.H., Effect of 2-amino-3-mecaptopropanic acid (cysteine) on the corrosion behaviour of low carbon steel in sulpharic acid, Electrochim. Acta, 2007, vol. 53, p. 909.
  20. de Souza, F.S. and Spinelli, A., Caffeic acid as a green corrosion inhibitor for mild steel, Corros. Sci., 2009, vol. 51, p. 642.
  21. Abd El-Lateef, H., Soliman, K.A., and Tantawy, A.H., Novel synthesized Schiff Base-based cationic Gemini surfactants: electrochemical investigation, theoretical modeling and applicability as biodegradable inhibitors for mild steel against acidic corrosion, J. Mol. Liq., 2017, vol. 232, p. 478.
  22. Magaino, S., Corrosion rate of copper rotating disk electrode in simulated acid rain, Electrochim. Acta, 1997, vol. 42, no. 3, p. 377.
  23. Arhad, N., Akram, A.R., and Akram, M., Triazolothiadazine derivatives as corosion inhibitors for copper, mild steel and aluminum surfaces: electrochemical and quantum investigations, Prot. Met. Phys. Chem. Surf., 2017, vol. 53, no. 2, p. 343.
  24. Tasic, Z.Z., Antonijevic, M.M., and Petrovic Mihajlovic, M.B., The influence of synergetic effects of 5‑methyl-1H-benzotrioazole and potassium sorbate as well as 5-methyl-1H-benzotrizole and gelatin on the copper corrosion in sulphuric acid solution, J. Mol. Liq., 2016, vol. 219, p. 463.
  25. Subramanian, R. and Lakshmiarayanan, V., Effect of adsorption of some azoles on copper passivation in alkaline medium, Corros. Sci., 2002, vol. 44, p. 535.
  26. Badawy, W.A., Ismail, K.M., and Fathi, A.M., The influence of the copper/nickel ratio on the electrochemical bahaviour of Cu–Ni alloys in acidic sulfate solutions, J. Alloys Compd., 2009, vol. 484, nos. 1–2, p. 365.
  27. Gece, G., The use of quantum chemical methods in corrosion inhibitor studies, Corros. Sci., 2008, vol. 50, p. 2981.
  28. El Ibrahimi, B., Soumoue, A., and Jmiai, A., Computational study of some triazole derivatives (un- and protonated forms) and their copper complexes in corrosion inhibition process, Absolute electronegativity and hardness correlated with molecular orbital theory, J. Mol. Struct., 2016, vol. 1125, p. 93.
  29. Pearson, R.G., Absolute electronegativity and hardness correlated with molecular orbital theory, Proc. Natl. Acad. Sci., 1986, vol. 83, p. 8440.
  30. Zarrouk, A., Zarrok, H., and Salghi, R., A theoretical investigation on the corrosion inhibition of copper by quinoxaline derivatives in nitric acid, Int. J. Electrochem. Sci., 2012, vol. 7, no. 7, p. 6353.
  31. Bedair, M.A., The effect of structure parameters on the corrosion inhibition effect of some heterocyclic nitrogen organic compounds, J. Mol. Liq., 2016, vol. 219, p. 128.
  32. Milic, S.M. and Antonijevic, M.M., Some aspects of copper corrosion in presence of benzotriazole and chloride ions, Corros. Sci., 2009, vol. 51, no. 1, p. 28.
  33. El-Sayed Sherif, M., Erasmus, R.M., and Comins, J.D., Corrosion of copper in aerated synthetic sea water solutions and its inhibition by 3-amino-1,2,4-triazole, J. Colloid Interafce Sci., 2007, vol. 309, p. 470.
  34. Prabakaran, M., Vadivu, K., and Ramesh, S., Corrosion protection of mild steel by a new phosphonate inhibitor system in aqueous solution, Egypt. J. Pet., 2014, vol. 23, no. 4, p. 367.
  35. Migahed, M.A., Attya, M.M., and Rashwan, S.M., Synthesis of some novel non ionic surfactants based on tolytriazole and evaluation their performance as corrosion inhibitors for carbon steel, Egypt. J. Pet., 2013, vol. 22, p. 149.
  36. Fouda, A.S. and Wahed, H.A., Corrosion inhibition of copper in HNO3 solution using thiphene and its derivatives, Arab. J. Chem., 2016, vol. 9, p. 91.
  37. Scendo, M., Inhibitive action of the purine and adenine for copper corrosion in sulphate solutions, Corros. Sci., 2007, vol. 49, p. 2985.
  38. Petrovic, M.M., Radovanovic, M.B., Tasic, Z.Z., and Antonijevic, M.M., Imidazole based compounds as copper corrosion inhibitors in seawater, J. Mol. Liq., 2017, vol. 225, p. 127.
  39. Amin, M.H., Weight loss, polarization, electrochemical impedance spectroscopy, SEM and EDX studies of the corrosion inhibition of copper in aerated NaCl solutions, J. Appl. Electrochem., 2006, vol. 36, p. 215.
  40. Larabi, L., Benali, O., and Mekelleche, S.M., 2-mercapto-1-methylimidazole as corrosion inhibitor for copper in hydrochloric acid, Appl. Surf. Sci., 2006, vol. 253, p. 1371.